Fairchild 公司的FAN6863是高度集成的反激電源綠模式PWM控制器，設計用在小于40W和待機功耗小于100mW的消費類電子產品如適配器，機頂盒（STB），上網本等. FAN6863的起動電流為8uA，綠模式（Green Mode）的工作電流600uA，具有軟驅動以降低EMI，主要用在通用的開關電源和反激電源轉換器。本文介紹了FAN6863主要特性，方框圖以及起動電路圖和應用電路圖。
FAN6863：Highly Integrated Green-Mode PWM Controller
A highly integrated PWM controller, FAN6863 provides several features to enhance the performance of flyback converters. To minimize standby power consumption, a proprietary Green Mode provides off-time modulation to continuously decrease the switching frequency under light-load conditions. Under zero-load conditions, the power supply enters Burst Mode, which completely shuts off PWM output. Output restarts just before the supply voltage drops below the UVLO lower limit. Green Mode enables power supplies to meet international power conservation requirements.
The FAN6863 is designed for SMPS and integrates a frequency-hopping function that helps reduce EMI emission of a power supply with minimum line filters.
The built-in synchronized slope compensation provides proprietary sawtooth compensation for constant output power limit over universal AC input range. The gate output is clamped at 13.5V to protect the external MOSFET from over-voltage damage.Other protection functions include SENSE pin Short- Circuit Protection (SSCP), VDD Over-Voltage Protection (OVP), and Over-Temperature Protection (OTP). For OTP, an external NTC thermistor can be applied to sense the ambient temperature. When VDD OVP or OTP is activated, an internal latch circuit latches off the controller.
FAN6863主要特性：
Low Standby Power: Under 0.1W
Low Startup Current: 8μA
Low Operating Current at Green Mode: 600μA
Peak-Current Mode Operation with Cycle-by-Cycle Current Limiting
PWM Frequency Continuously Decreasing with Burst Mode at Light Loads
VDD Over-Voltage Protection (OVP)
Constant Output Power Limit (Full AC Input Range)
Internal Latch Circuit (FAN6863L) for OVP, OTP
SENSE Pin Short-Circuit Protection (SSCP)
Fixed PWM Frequency (65KHz) with Frequency Hopping
Feedback Open-Loop Protection: 60ms Delay
GATE Output Maximum Voltage Clamp: 13.5V
Soft-Start Time: 5ms
Soft Driving for EMI Improvement
Full Range Frequency Hopping
Internal OTP Sensor with Hysteresis
?
GATE Driving Capability: 400mA
FAN6863應用：
General-purpose switched-mode power supplies and flyback power converters, including:
?
Power Adapters
?
Open-Frame SMPS
?
SMPS with Surge-Current Output, such as for Printers, Scanners, Motor Drivers
圖1。FAN6863方框圖
圖2。FAN6863典型應用電路圖
圖3。FAN6863起動電路圖
圖4。FAN6863詳細的應用電路圖
詳情請見：
http://www.fairchildsemi.com/ds/FA/FAN6863.pdf
